Since Triton’s starboard propeller is driven by the forward engine, it follows that the starboard propeller shaft must be much the longer of the two. About midway in its length, its great weight had necessitated installation of a “spring bearing”—merely a line or support bearing to keep it turning true—and it was here, in the most ordinary of standard mechanisms, that the evil little god of misfortune had decreed that difficulty should develop. The first sign of trouble was a rise in the lubricating oil temperature.
Ordinarily, when in receipt of such a report, the immediate thing to do is slow down; but since the initial sea trials were being run by Admiral Rickover, I first sought him out to see what he desired. His red-bound book lay closed on the tool box by the de-aerating feed tank, and I found him down in the lower level of number two auxiliary machinery compartment, where the offending spring bearing was located high in the starboard after corner. When I arrived, the entire group of designers and engineers aboard for the trials were already present; and the gray-haired birdlike Admiral had climbed up into the corner for a close inspection, squeezing his wiry frame into the cramped space between the swiftly rotating propeller shaft and the curved hull of the ship, alongside the huge steel box containing the bearing.
“We’re going to have to cut the power, Ned,” said one of the bystanders, an Electric Boat supervisor. “It’s too bad, but we can’t take a chance on wiping this bearing.”
This was the evaluation I sensed from everyone present. The decision, however, was Rickover’s, as the officer responsible for the initial sea trials. He had evidently been listening to the bearing with a large screwdriver held against his head, and I got there just as Les Kelly handed up a stethoscope taken from one of our repair kits.
Long minutes passed while Rickover listened at various spots on the bearing housing. There was a grim set to his jaw when he descended at last from his perch alongside the housing. “There’s not a thing wrong with the bearing,” he said shortly. “It’s working exactly as designed, but it’s not designed right.”
“We’ve already proved the designed power of the ship, Admiral,” said the Electric Boat representative who had spoken with me. “We’ll get right on the bearing as soon as we get back to the Boat Division. I’m sure our designers can figure out what’s wrong….”
“The only thing wrong is that it needs more cooling. Any fool can see that,” cut in Rickover. “Besides, we’re not going back. Not yet—Kelly!” Abruptly he shifted his attention to Triton’s Chief Engineer. “Rig a hose. Get a constant spray of water going on the bearing housing. Set a special watch on the lube oil temperature!”
“But Admiral,” protested the EB man, “there’s no need to subject the bearing to additional stress. We’ve already satisfied the design specs, and there’s no point to going further …”
Admiral Rickover’s voice held a curiously flat, monotonous tone, which I had heard before. “We’re here to find out if this ship is satisfactory for war. I’ll not let this piece of lousy designing stop the trial, and I’ll take the responsibility if it breaks down!” There was a singular lack of emphatic expression in the way Rickover spoke, effectively belied by the flinty look in his eyes.
Within minutes, Les Kelly had a squad of his men dragging a rubber hose to the vicinity, and a spray of salt water was played upon the steel box enclosing the defective bearing and its oil supply. A constant check of the oil temperature was set up, with results reported to Admiral Rickover and, upon my private instructions to Les, to me. In the meantime, Triton had not slowed her headlong dash through the water, and after a few more minutes, to our relief, the lube oil temperature from the starboard propeller shaft spring bearing stopped its steady rise.
We watched it carefully from this point on, and the design for a permanent “fix”—installation of the oil-cooling system which should have been there from the beginning—was complete in all essentials by the time Triton returned to the EB docks. Except for our natural concern that the temperatures continue to remain under control, the bearing gave us no further trouble, the all-out power test continued, and Admiral Rickover, with Les Kelly’s stethoscope forgotten in his pocket, went back to his tool chest and his book.
Both Les and I were greatly heartened by the outcome of the apparent breakdown, for, like all officers attached to Triton, we wanted more than anything else to know her real ability to respond when the chips were down. Should an emergency occur, we might have need of that extra little response—perhaps sooner than any of us could then anticipate.
As the trials progressed, the thrill of watching a magnificent engineering plant out-perform the highest expectations worked its heady magic on even Admiral Rickover. We kept every critical bearing and every mechanism under special surveillance, and maintained power, running hundreds of miles south in the process. With the over-steam-demand alarms sounding their piercing, ringing, hornlike noise throughout the vast engineering spaces, every indicator on the reactor and electric control panels touching—but not exceeding—its maximum-allowed value, the great reduction gears and turbines shrilling their joyful song of superhuman strength and dependability, Triton, deeply submerged, roared through the water with the speed of an express train.
It is, unfortunately, not within the province of this narrative to state the speed actually achieved by our ship, nor any of the specific parameters of her power plant, but I don’t suppose there can be any objection to revealing the title of the book Vice-Admiral Rickover was reading. I had snatched a glimpse of the name on the cover when it lay temporarily unguarded on the tool box. It was The Memoirs of a Renaissance Pope.
There are those who have claimed that the faster Triton went, the more slowly the Admiral read, and that toward the end he turned the pages very slowly indeed, if at all. As to this, I cannot testify, for I could not remain in the engine room; but my memory does record the impression, after the many hours and so very many miles, that the blank look he wore could only be a mask for his true delight.
The trials, an unqualified success in every way, became difficult only once, as a result of my own failure to appreciate fully the forces with which we were dealing. One of the tests required that the ship be operated submerged in the astern direction. I had done this before with Piper, Amberjack, and Trigger II, but I knew very well that it might be considerably more difficult with Triton, since she was much longer and bigger, and proportionately even more slender than they. She was also infinitely more powerful, a factor which I felt would tend to equalize the situation.
Some time after the completion of the main power trials, after a number of other evolutions had been successfully demonstrated, I directed Thamm, who was now OOD as well as Diving Officer of the Watch (the ship, deeply submerged, had no need for an officer at the periscope station in the conning tower), to reverse the engines and operate the ship astern.
“All stop,” barked Thamm. “All back two-thirds.”
We could feel the great bronze propellers swinging to a stop and picking up speed in the reverse direction. Our speed indicator began to slow rapidly, reached zero, where, unable to indicate reverse speeds, it stayed. Slowly we felt Triton gathering sternway, and Tom reversed the direction of action of his bow and stern planes in order to maintain correct depth. For a time all went very well, but then the ship began to oscillate with a great, slow seesaw motion, and at the same time she slowly increased depth. At first this was of no particular concern, but soon I realized that we were getting close to the ocean floor, and that a submarine of our great length could not be allowed to oscillate through very much of an angle before there might be danger of her striking bottom.